CoastalCorsa
Member
Registered: 7th Jan 05
Location: Lancashire
User status: Offline
|
This air horn kit has been used once [to test it works]
Most of the following info is taken from the manufacturers website.
Jericho Stage 2 Air Systems pack a big pump into a small integrated tank unit.
This is a sound clip, this will give you an idea of how loud
Specifications:
35 liter per minute 12vDC compressor
18 amp draw, fuse @25 amps
3 liter integrated air storage tank
120psi-on / 90psi-off pressure switch
135 psi safety valve
140 psi air gauge
3 -1/4" NPT ports
Built-in, relocatable, water drain
Can install in any orietantion
Performance:
This unit holds enough air to operate any of our air horns and produce ear-splitting amounts of sound.
The pump in this unit is STRONG & FAST!
Unlike most of the mouse-motored 3 liter units on the market, there are no 5-8 minute refill times here. The Jericho Stage 2 pump gives a 0-120psi cycle time of about 90 seconds! 90psi-120psi re-charges happen in about a half minute.
Endurance:
The devil is in the details... This is where we set ourselves apart!
Take note of the copper air line running from the pump to the tank. Copper lines are highly unusual in 3 liter air systems. You should be asking why we used a harder to fit and install copper air line.
If you want to read about seige engineering - http://www.siege-engineering.com/AboutUs.aspx
This is a sound clip, this will give you an idea of how loud
I paid £125 for the full kit,Ideally I want £125 but I am open to offers.
Postage is £10 via DHL - Any offer over £110 can have free courier
Complete 120psi 5 Liter Air System & Train Horn Package!
This item includes:
Air Horn -a Genuine Siege Engineering Product
5 Liter Self-Contained 120psi Air System
GMAX High Flow Valve
Logo'd Caps Upgrade
Check Valve Upgrade
Wiring Harness with Relay
20' 3/8in BIG Air Hose
Fittings & Misc Parts
Installation Guide Written for the First Time Installer
Jericho 5 Liter Air System Description:
Our Jericho 5 Liter Systems are a great and simple way to setup an air system. Jericho systems are pre-assembled and pre-tested for 6 run cycles at the end of our production line. We then perform a wait-test to check for slow-leaks. (This means you will find remnants of thread tape in the ports where we plugged the tank during testing!)
Our Jericho air system are now in their 3rd generation and have a number of differences to consider if you are shopping around for an air system package.
Compare Jericho air systems to other air systems which may look similar! -Ask your vendor some questions!
This is a 120psi unit, not 110psi!
All parts externally accessible for easy maintenance -no hidden fittings you can't service!
Upgraded brush design for longer motor life
Hi-temp silicon head gasket
Corrosion-resistant flapper valve
Machine welded seams
Powder coated tank exterior
The pump body and pump head on this system are made of metal, NOT silver painted plastic!
The pump to tank air line is made of copper, NOT plastic. The copper air line DOES NOT MELT when abused.
The piston rod and cam are made of forged steel not plastic
A 30mm piston (not a 20 or 25mm piston)
A 2 minute 90-120psi fill time versus need 4+ minutes on some other units...
The motor is heavy duty enough to support an expansion tank up to 4 liters.
Three 1/4inNPT ports with standard American pipe threads, reinforced and welded. The fittings at your hardware store are a perfect match.
This system is built with a check valve. The check valve stops 'pump leakage'. Without a check valve, air systems leak down quickly, run more often, and wear out faster (even if you are not using your horn!) Most other compact air systems on the market do NOT have this feature.
This system has a safety valve like all compressors are supposed to! The safety valve is also handy for draining the tank when you do maintenance.
Reinforced, welded 1/4inNPTdrain port. See our picture and compare to other vendors who glue a fitting into this port. Glues fittings do NOT hold up well to frequent use.
Tank interior is coated with rust-inhibitor.
We carry replacement parts! Some vendors send you to "factory warranty service." Where is the factory?
Jerich Air System Description
The Jericho 5L air system is about the same diameter as a 3 liter soda bottle, and about 21 inches long. It weighs about 15 pounds and runs on 12vDC power from a car or truck battery.
This Jericho 5L system gives a few seconds of blast time then automatically re-fills. The air system is quieter than most compact systems we have listened to but is by no means whisper quiet. We suggest installing it in the trunk.
This is a seriously loud horn.
video clips of similar horns can be found on the internet - youtube / Hornblasters.com and others
if your interested send me a pm
This is a sound clip, this will give you an idea of how loud
£125 ONO
|
VegasPhil
Premium Member
Registered: 16th Jan 05
Location: Fareham, Hants Drives: Octavia VRS
User status: Offline
|
 Awesome!
Corsa 2.0 16v Vegas - Sold
|
Kurt
Member
Registered: 23rd Oct 05
Location: Hi
User status: Offline
|
my brother has something like this on his wagon 
|
GteRedtop
Member
Registered: 13th Jun 07
Location: Your mother's Otter's pocket
User status: Offline
|
why is it ideal for xe or let drivers, lol
|
sri_davie
Member
Registered: 8th Aug 04
Location: Glasgow
User status: Offline
|
id love that but where id put the trumpets is beyond me looked at them at pvs
davie
|
CoastalCorsa
Member
Registered: 7th Jan 05
Location: Lancashire
User status: Offline
|
quote:
Originally posted by GteRedtop
why is it ideal for xe or let drivers, lol
To warn people your coming thru....... and to get out of ya way
|
CoastalCorsa
Member
Registered: 7th Jan 05
Location: Lancashire
User status: Offline
|
quote:
Originally posted by sri_davie
id love that but where id put the trumpets is beyond me looked at them at pvs
davie
Best place is above the sh1t guard on the passenger side or some where behind the bumper but before the radiator.
|
sri_davie
Member
Registered: 8th Aug 04
Location: Glasgow
User status: Offline
|
i had a look by the time my radiators in, oil cooler and intercooler its doesnt leave much room at all, and im replacing the splash guards with the protec ones so thats filling in some of the room 
davie
davie
|
Scotty C
Member
Registered: 6th Nov 05
Location: Kidderminster Drives: 1.6 16v Sport
User status: Offline
|
Fook me 
|
